Magnesium Technology 2012

Front Matter....Pages ii-xxv
Front Matter....Pages 1-1
Magnesium Alloy Development using Phase Equilibria Computation and Microstructure Validation....Pages 3-3
Atoms-to-Grains Corrosion Modeling for Magnesium Alloys....Pages 5-9
Solid State Joining of Magnesium to Steel....Pages 11-16
Grain Evolution during High Temperature Necking of Magnesium Alloys....Pages 17-21
Production of wide shear-rolled magnesium sheet for part forming....Pages 23-28
Front Matter....Pages 29-29
Carbothermal Production of Magnesium: Csiro’s Magsonic™ Process....Pages 31-35
Magsonic™ Carbothermal Technology Compared with the Electrolytic and Pidgeon Processes....Pages 37-41
Scaling-Up Solid Oxide Membrane Electrolysis Technology for Magnesium Production....Pages 43-48
Fluid Bed Dehydration of Magnesium Chloride....Pages 49-53
Demonstration of Solar-Pumped Laser-Induced Magnesium Production form Magnesium Oxide....Pages 55-58
Molten Salt Electrolysis of MgCl2 in a Cell with Rapid Chlorine Removal Feature....Pages 59-62
Preparation of aluminum-magnesium alloy from magnesium oxide in RECl3-KCl-MgCl2 electrolyte by molten salts electrolysis method....Pages 63-66
Experimental Study on Magnesium Extracted from Ascharite Mineral by Aluminium....Pages 67-69
Electrochemical investigation on chlorine and electrolyte intercalation into graphite anodes during magnesium electrolysis process....Pages 71-73
Optimization of Preparation for Magnesium Oxide by Calcination from Basic Magnesium Carbonate Using Response Surface Methodology....Pages 75-79
Front Matter....Pages 81-81
An Elasto-Plastic Micromechanical Method for Twin Driven Plasticity....Pages 83-86
Anomalous Twin Bands in AZ31 Magnesium Sheet Bending....Pages 87-92
Formation of Nano-Scale Twins and Low Angle Grain Boundaries during Fracture of a Fine Grained Magnesium Alloys....Pages 93-97
Tensile and Creep Deformation Mechanisms in Rolled AZ31....Pages 99-104
Structural Origin of Reversible Twinning, Non-Schmid Effect, Incoherent Twin Boundaries and Texture in Hexagonal Close-Packed Metals....Pages 105-110
Front Matter....Pages 81-81
Length Changes in Extruded Magnesium Alloy Bars Under Large Strain Free-End Torsion....Pages 111-116
Nano-Indentation Studies of Twinned Magnesium Single Crystals....Pages 117-119
Non-Basal Textures in Magnesium Alloy Strips Produced by Extrusion-Machining....Pages 121-125
The Elasto-Plastic Transition in Magnesium Alloys....Pages 127-131
Front Matter....Pages 133-133
Twin Roll Casting of Thin AZ31 Magnesium Alloy Strip with Uniform Microstructure and Chemistry....Pages 135-140
Mathematical Modeling of the Twin Roll Casting Process for AZ31 Magnesium Alloy - Effect of Set-Back Distance....Pages 141-144
Intermetallic Phase Formation and Growth in the Mg-Y System....Pages 145-148
Microstructure and Mechanical Properties of High Pressure Die Cast AM50 Magnesium Alloy Containing Ce....Pages 149-154
Melt Conditioned DC (MC-DC) Casting of Magnesium Alloys....Pages 155-160
Effect of the Solidification Rate on Microstructure of Cast Mg Alloys at Low Superheat....Pages 161-164
Impact and Energy Dissipation Characteristics of Squeeze and Die Cast Magnesium Alloy AM60....Pages 165-168
Sliding Wear Behaviour of Squeeze Cast Magnesium Composite AM60-9% (Al2O3)f....Pages 169-174
Solidification Studies of Mg-Al Binary Alloys....Pages 175-178
Front Matter....Pages 179-179
Age hardening behavior of Mg-1.2Sn-1.7Zn alloy containing Al....Pages 181-185
Effect of Nano-Alumina and Copper Micron Size Particulates on Microstructure and Mechanical Properties of Magnesium Alloy AZ31....Pages 187-189
Evaluating the effect of pre-ageing deformation on β′ precipitate size and distribution in Mg-Zn(-Y) Alloys....Pages 191-196
Effect of Zinc Content on the Microstructure and Mechanical Properties of Extruded Mg-Zn-Y-La Alloys with LPSO Phase....Pages 197-199
Effect of Ca Addition on the Microstructural and Mechanical Properties of AZ51/1.5Al2O3 Magnesium Nanocomposite....Pages 201-206
Effect of Zn Concentration and Grain Size on Prismatic Slip in Mg-Zn Binary Alloys....Pages 207-211
Effects of Ca on Microstructure and Mechanical Properties of ZA62 Alloys....Pages 213-216
Front Matter....Pages 179-179
Mechanical Properties and High-Temperature Oxidation Behavior of Mg-Al-Zn-Ca-Y Magnesium Alloys....Pages 217-219
Effects of Si on microstructure and mechanical properties of Mg-5Sn-2Sr alloy....Pages 221-225
Front Matter....Pages 227-227
“Electroless” E-Coating for Magnesium Alloys....Pages 229-234
The Influence of Galvanic Current on Cerium-Based Conversion Coatings on Mg, Al, and Galvanized Steel Couples....Pages 235-239
Effect of Sn4+ Additives on the Microstructure and Corrosion Resistance of Anodic Coating Formed on AZ31 Magnesium Alloy in Alkaline Solution....Pages 241-245
Effect of Thickness on the Morphology and Corrosion Behavior of Cerium-Based Conversion Coatings on AZ31B Magnesium Alloy....Pages 247-251
Mechanical and Corrosion Properties of as-cast and Extruded MG10GD alloy for Biomedical Application....Pages 253-259
Corrosion Behavior of Various Steels by AZ31 Magnesium Melt....Pages 261-264
Corrosion of Ultrasonic spot Welded Joints of Magnesium to Steel....Pages 265-269
Effect of some Microstructural Parameters on the Corrosion Resistance of Magnesium Alloys....Pages 271-276
Influence of Aluminum Content on Corrosion Resistance of Mg-Al Alloys Containing Copper and Zinc....Pages 277-280
Front Matter....Pages 281-281
Effect of rolling temperature on the AZ31B magnesium alloy microstructure....Pages 283-287
Hot Formability Curves for Four AZ31B Magnesium Alloy Sheets Obtained by the Pneumatic Stretching Test....Pages 289-294
Texture evolution during hot deformation processing of Mg-3Sn-2Ca-0.4Al Alloy....Pages 295-300
The effects of strain and stress state in hot forming of mg AZ31 sheet....Pages 301-306
Effect of Strain Rate on Dynamic Recrystallization in a Magnesium Alloy Under Compression at High Temperature....Pages 307-310
Effect of Strain Rate on the Kinetics of Hot Deformation of AZ31 with Different Initial Texture....Pages 311-316
Precipitation behaviour of micro-alloyed Mg-AL-CA alloys during heat treatment and hot compression....Pages 317-322
Diffusion couple investigation of the Mg-Zn system....Pages 323-327
Biaxial Deformation Behavior of AZ31 Magnesium Alloy at High Temperatures....Pages 329-332
Front Matter....Pages 333-333
Microstructure Modeling of Magnesium Alloys for Engineering Property Prediction....Pages 335-337
Microstructure Modification and Deformation Behavior of Fine Grained AZ61L Sheet Produced by Thixomolding® and Thermomechanical Processing....Pages 339-344
Development of High Strength and Toughness Magnesium Alloy by Grain Boundary Control....Pages 345-347
Effects of Direct Extrusion Process on Microstructure, Texture Evolution and Yield Strength of Magnesium Alloy AZ31....Pages 349-354
Comparison of Tensile Properties and Crystallographic Textures of Three Magnesium Alloy Sheets....Pages 355-360
Strain Hardening of ZK60 Magnesium Alloys....Pages 361-364
Strain-Rate Effects of Sand-Cast and Die-Cast Magnesium Alloys under Compressive Loading....Pages 365-370
Mechanical Properties of Mg Alloys AMX602 and AZXE7111 under Quasi-Static and Dynamic Loading....Pages 371-375
Front Matter....Pages 383-383
The Effect of Friction Stir Processing on Microstructure and Tensile Behavior of Thixomolded AZ91 Magnesium Alloy....Pages 391-396
Effect of Weld Structure on Fatigue Life of Friction Stir Spot Welding in Magnesium AZ31 Alloy....Pages 397-402
Effect of Corrosion on the Tensile Properties of Friction-Stir Welded AZ31B Sheet....Pages 403-408
On the Effect of Ti2AlC on the Formation of Thermally Stable Mg Nano Grains....Pages 409-412
Experimental Investigations into the Deformation Behavior of Thixo-Molded Mg AZ61L Sheet Alloy....Pages 413-418
Effects of High-temperature Shot Peening on Surface Characteristics and Fatigue Properties of Forged AZ31 Magnesium Alloys....Pages 419-422
Solid Solution Hardening Effect of Aluminum on the Creep Deformaton of AZ91 Magnesium Alloy....Pages 423-426
Front Matter....Pages 427-427
Enhancement of Strength and Ductility of Mg96Zn2Y2 Rolled Sheet by Controlling Structure and Plastic Deformation....Pages 429-432
Microstructural Characteristics of High Rate Plastic Deformation in Elektron™ WE43 Magnesium Alloy....Pages 433-438
Microstructure and Mechanial Properties of As-extruded Mg-Sn-Al-Zn Alloys....Pages 439-442
Tensile Properties Of Three Preform-Annealed Magnesium Alloy Sheets....Pages 443-448
The Role of Intermetallics on Creep Behaviour of Extruded Magnesium Alloys....Pages 449-454
Front Matter....Pages 427-427
High Performance MG-System Alloys For Weight Saving Applications: First Year Results From The Green Metallurgy EU Project....Pages 455-459
Effect of Extrusion Conditions on Microstructure and Texture of Mg-1% Mn and Mg-1% Mn-1.6% Sr Alloys....Pages 461-464
Microstructural Characterization of Homogenised and Aged Mg-Gd-Nd-Zn-Y-Zr Alloys....Pages 465-468
On the Deformed Microstructure of Rolled Mg-2.9Y....Pages 469-473
Front Matter....Pages 475-475
In-Vitro Corrosion Studies of Bioabsorbable Alloys....Pages 477-482
High-Capacity Hydrogen-Based Green-Energy Storage Solutions For The Grid Balancing....Pages 483-488
Reaction Sintering of Mg2Si Thermoelectric Materials by Microwave Irradiation....Pages 489-492
Charge-Discharge Mechanism of MgC powders and Mg-Li Alloy Thin Film Materials....Pages 493-497
Control of Yttrium Diffusion out of Yttria Stabilized Zirconia during SOM Electrolysis for Magnesium Production....Pages 499-503
Study on the Thermodynamic and Experimental Carbothermic Reduction of Garnierite....Pages 505-510
Mechanism of Carbothermic Reduction of Magnesia and Reversion Reaction....Pages 511-516
Front Matter....Pages 517-517
Combination of Cooling Curve and Micro-Chemical Phase Analysis of Rapidly Quenched Magnesium AM60B Alloy....Pages 519-524
Effects of Friction Stir Process on the Tensile Properties of AZ61 Magnesium Alloy at Room Temperature to 200 °C....Pages 525-529
Magnesium Recycling of Partially Oxidized, Mixed Magnesium-Aluminum Scrap through Combined Refining and Solid Oxide Membrane (SOM) Electrolysis Processes....Pages 531-535
Microstructure and mechanical properties of Mg-5Sn-5Zn-xCa alloys....Pages 537-541
Phase dissolution of γ-Mg17Al12 during homogenization of as-cast AZ80 Magnesium alloy and its effect on room temperature mechanical properties....Pages 543-548
Precipitate Formation and Grain Refinement of MG-AL-SN Alloy during Hot Deformation....Pages 549-554
The effect of precipitation on the mechanical properties of extruded AZ80....Pages 555-559
Influence of Section Thickness on Microstructure and Mechanical Properties of Squeeze Cast Magnesium Alloy AM60....Pages 561-564
Back Matter....Pages 565-571