Energy Materials 2014: Conference Proceedings

Front Matter....Pages i-xvii
Front Matter....Pages 1-1
The State-of-the-Art of Materials Technology Used for Fossil and Nuclear Power Plants in China....Pages 3-11
Energy Efficient Materials Manufacturing from Secondary Resources....Pages 13-22
Development and Applications of Pipeline Steel in Long-Distance Gas Pipeline of China....Pages 23-31
Factors Affecting the High Temperature Performance of Creep Strength Enhanced Ferritic Steels....Pages 33-42
Development of Advanced Ods Ferritic Steels for Fast Reactor Fuel Cladding....Pages 43-52
Development of Microalloyed Steels for The Oil and Gas Industry....Pages 53-60
Enhancing the Weldability of C-Mn Pressure Vessel Steels — A Tale of Two Elements....Pages 61-70
Corrosion of Advanced Steels: Challenges in the Oil and Gas Industry....Pages 71-79
Design Against Propagating Shear Failure in Pipelines....Pages 81-99
Front Matter....Pages 101-101
The Development of Boiler Pipes Used for 700°C A-USC-PP in China....Pages 103-110
Creep Strength Behavior of Boron Added P91 Steel and its Weld in the Temperature Range of 600–650°C....Pages 111-121
Development of Ferritic Heat-Resistant Steels Based on New Materials Design Concept for Advanced High Efficiency Power Plants....Pages 123-128
Alloy Design of Martensitic 9Cr-Boron Steel for A-USC Boiler at 650 °C — Beyond Grades 91, 92 and 122....Pages 129-136
Effect of Preferential Heat Treatment on Microstructure of New Martensitic Heat Resistant Steel G115....Pages 137-143
Study on Phase Stability of New Ni Based Superalloy Less 1 Designed to Low the ETA and Sigma Phase Fraction at 700 °C....Pages 145-150
Research on the Superheater Material Properties for USC Boiler with 700°C Steam Parameter....Pages 151-159
Creep-Rupture Behavior of Ni-Based Alloy Tube Bends for A-USC Boilers....Pages 161-168
Performance Evaluation and Analysis for P92 Extrusion Pipes....Pages 169-174
Effect of Alloying Additions on Oxidation Behaviors of Ni-Fe Based Superalloy for Ultra-Supercritical Boiler Applications....Pages 175-184
An Experimental Study on the Low Cycle Fatigue Behaviors of Domestic IP Rotor Steel for 1000MW Ultra-Supercritical Turbine....Pages 185-192
Front Matter....Pages 101-101
The Microstructural Evolution of Haynes 282 Alloy During Long-Term Exposure Tests....Pages 193-202
Alloy 740H Component Manufacturing Development....Pages 203-210
Advances in Large Nickel Alloy Turbine Castings for +700°C Operation....Pages 211-218
Benchmarking of Influential Factors and Energy Consumption in Shougang Three Plants....Pages 219-226
Development of Advanced Heat Resistant Materials for IGCC And AUSC Power Plants....Pages 227-234
Stability of Microstructure and Mechanical Properties of a Ni-Based Superalloy for Advanced Ultra-Supercritical Fossil Power....Pages 235-241
Studies on High Temperature Corrosion of Austenitic Heat-resistant Steels Super 304H/10Cr18Ni9Cu3NbN in Simulated and Real Combustion Gas Atmospheres....Pages 243-250
The Effect of Shot Peening on the Oxidation Resistance of Super304H Steels in Water Vapor....Pages 251-259
Relationship between Microstructure and Properties under Simulated On-Fire Processing Conditions of Q345R Boiler Steel....Pages 261-269
Recent Developments in Niobium Containing Austenitic Stainless Steels for Thermal Power Plants....Pages 271-277
Effect of Heattreatment on the Microstructure and Properties of Cold-worked Inconel 740H Boiler Tubes....Pages 279-285
Development and Application of TMCP Steel Plate in Coal Mining Machinery....Pages 287-298
Study on Dynamic Strain Aging and Low-Cycle Fatigue of Stainless Steel in Ultra-Supercritical Unit....Pages 299-306
Microstructure Changing of P91 Heat Resistant Steel during Short-Term Creep at 873K....Pages 307-313
Effect of Solution Temperature on the Microstructure and Mechanical Properties of Nickel Based Alloy CN 617....Pages 315-320
Effects of Mo Content on Microstructure and Mechanical Property of PH13-8Mo Martensitic Precipitation-Hardened Stainless Steel....Pages 321-326
Stress Corrosion Behavior of 12Cr Martensite Steel for Steam Turbine LP Blade....Pages 327-332
Creep Behavior and Microstructure Evolution of P92 Steel During Creep Test at 873 K....Pages 333-342
Study of Cleanliness of High Nitrogen Steel in ESR....Pages 343-349
Effects of Packed Structure and Operation Conditions on Liquid Flow Behavior in Blast Furnace Hearth....Pages 351-356
Front Matter....Pages 101-101
Hot Deformation Behavior of NF709 Austenitic Heat-Resistant Steel....Pages 357-363
Material Challenges for Long Term and Safe Operation of Coal Gasification Systems....Pages 365-372
Effect of Surface Condition on the Oxidation Behavior of HK40 Alloy under Low Oxygen Partial Pressure....Pages 373-378
Front Matter....Pages 379-379
Influence of Wall Thickness on Microstructure of the Directionally Solidified Turbine Vane with High Withdrawal Rate....Pages 381-386
Influence of Cu and Zn Residues from Wire Electro-Discharge Machining on TBC Durability....Pages 387-392
Experience in Manufacture and Behaviours of High Chromium Forged Rotor Steels....Pages 393-404
Damage Analysis of a Retired Gas Turbine Disc....Pages 405-410
Computer Aided Design of Ni-Based Single Crystal Superalloy for Industrial Gas Turbine Blades....Pages 411-416
Effects of Al on Coherent γ′, Lattice Misfit of γ′/γ and Stress-Rupture Property of Nimonic 80A....Pages 417-423
The Application of 9% Cr Casting Steel with Co and B Addition for 620°C Steam Turbine....Pages 425-430
Front Matter....Pages 431-431
Advanced Steels for Accident Tolerant Fuel Cladding in Current Light Water Reactors....Pages 433-442
Development of Mono-bloc Forging for CAP1400 Reactor Pressure Vessel....Pages 443-450
Separation of Zirconium and Hafnium: A Review....Pages 451-457
Research on M23C6 precipitation of 690 alloy....Pages 459-465
Preliminary Investigation on Brazing Performance of OFHC Tube Butt-Joints....Pages 467-471
Hot deformation constitutive equation and processing map of Alloy 690....Pages 473-480
Thermal Aging Performance of Domestic Cast Austenitic Stainless Steels in Nuclear Power Plants....Pages 481-486
Analysis of Heat Treatment for Martensitic Stainless Steel Used in CRDM....Pages 487-492
Study on Material Selection of Reactor Pressure Vessel of SCWR....Pages 493-499
Study on LBB Behavior of Nuclear Primary Pipes After Long-Term Thermal Aging....Pages 501-508
Front Matter....Pages 431-431
The Anatomy of AP1000 Mono-Block Low Pressure Rotor Forging....Pages 509-513
Research on the Domestic Materials of Forging Z12CN13 Stainless Steel for Hold-Down Spring of Reactor....Pages 515-521
Development of Profile Forging for Channel Head of Ap/Acp Steam Generator....Pages 523-531
Study About Ceiling Design for Main Control Room of NPP with HFE....Pages 533-538
Radiography Inspection Technology of CPR1000 Nuclear Power Unit Pressurizer....Pages 539-544
Study of girth weld selection principles and solution of inaccessible girth weld for high wear factor pipe in pre-service inspection....Pages 545-550
Effect of Heat Treatment on the Microstructure and Properties of 9Cr2WVTa Reduced Activation Steels....Pages 551-556
Determination of Intergranular Corrosion Susceptibility of Z3CN20.09M Cast Duplex Stainless Steel by a Modified Double Loop Electrochemical Potentiokinetic Reactivation Method....Pages 557-562
Front Matter....Pages 563-563
Corrosion in the Oil and Gas Industry: An Increasing Challenge for Materials....Pages 565-574
Automatic Measurement of Centreline Segregation in Continuously Cast Line Pipe Steel Slabs....Pages 575-581
Latest Development and Application of Nb-Bearing High Strength Pipeline Steels....Pages 583-595
Study on the Toughness of X100 Pipeline Steel Heat Affected Zone....Pages 597-604
Development of Higher Ductility and Lower Strain Aging Sensitivity X90/X100 Pipeline Steel....Pages 605-611
Research and Development of Ultra-High Strength X100 Welded Pipe....Pages 613-621
Effect of Cooling Mode on Microstructure and Mechanical Properties of Pipeline Steel for Strain Based Design and Research on its Deformation Mechanism....Pages 623-628
Influence of Ni and Mn on Microstructure and Mechanical Properties of Coarse Grain Heat Affected Zone in Low Carbon Microalloyed Steel....Pages 629-637
Austenite Grain Size Control in Upstream Processing of Niobium Microalloyed Steels by Nano-Scale Precipitate Engineering of TiN-NbC Composite....Pages 639-650
The Effect of Tempering Process on Microstructural Characteristics and Mechanical Properties of Induction Bend Pipe....Pages 651-656
Weld Haz Properties in Modern High Strength Niobium Pipeline Steels....Pages 657-664
Optimum Design and Development of High Strength and Toughness Welding Wire for Pipeline Steel....Pages 665-672
Front Matter....Pages 563-563
Low-Carbon Metallurgical Concepts for Seamless Octg Pipe....Pages 673-678
Influence of Heat Treatments on Microstructure and Mechanical Properties of Oilfield used Alloy 925....Pages 679-685
Effects of Specimen Shape, Size and Initial Occupancy on the Thermal Desorption Spectrum of Hydrogen....Pages 687-692
High Temperature Properties Test and Research of 9Cr1Mo (P9) Seamless Pipe Used in Petrochemical Industry....Pages 693-701
Recent Developments of Advanced Austenitic and Duplex Stainless Steels for Oil and Gas Industry....Pages 703-709
Hydrogen Cracking in Gas Tungsten Arc Welding of an AISI Type 321 Stainless Steel....Pages 711-716
Development and Application of Alloy TDJ-028 Seamless Pipe for Sour Oil and Gas Wells....Pages 717-720
Effect of Hot-Bending Process on Microstructure and Mechanical Property of K65 Submerged ARC Welded Pipe....Pages 721-728
Micromechanical Behaviors of Multi-Phase High Performance Steels....Pages 729-736
Influence of Tempering Temperature on the Second Phase Precipitation and Properties of X60 Pipeline Steel....Pages 737-742
Research on Submarine Pipeline Steel with High Performance....Pages 743-750
Analysis of High Temperature Ductility of Pipeline Steel and Application to ASP® Production Line in Angang Steel Co. Ltd.....Pages 751-758
Characterization of Anisotropic Behavior for High Grade Pipes....Pages 759-765
Application of Advanced Materials in Petroleum Engineering....Pages 767-773
Evaluation of Environmentally Assisted Cracking of Armour Wires in Flexible Pipes, Power Cables and Umbilicals....Pages 775-780
The Analysis of Force on PDC Cutter....Pages 781-787
Influence of Chloride Ion and Temperature on the Corrosion Behavior of Ni-Fe-Cr Alloy 028....Pages 789-794
Front Matter....Pages 795-795
Applications of Steel Plates for Pressure Vessels in Gb150.2....Pages 797-804
Niobium Application, Metallurgy and Global Trends in Pressure Vessel Steels....Pages 805-813
Optimised use of High Strength Steels for Pressure Vessels by Application of Modern Design Methods According to European Standards....Pages 815-820
Front Matter....Pages 795-795
Evaluation of Stress Corrosion Resistance Properties of 15CrMoR(H) in H2S Environment....Pages 821-829
Development of High Performance Cr-Mo Steel Plate for Hydrogen Service in Wugang....Pages 831-838
Effect of Tempering Temperature on the Low Temperature Toughness of the Cr-Mo Alloyed Pressure Vessel Steels....Pages 839-844
Research and Development of Nb-Bearing Steel Plates for Pressure Vessels in China....Pages 845-854
Research on the Low Temperature Pressure Vessel Steel of Nisco....Pages 855-862
Development of High Heat Input Welding High Strength Steel Plate for Oil Storage Tank in Xinyu Steel Company....Pages 863-869
Current Situation and Development Trend of Stainless Steel Material Applied in Pressure Vessel....Pages 871-879
Development of 12Cr2Mo1VR (H) Steel Plate for Equipment under Hydrogen Atmosphere....Pages 881-885
Microstructure and Impact Toughness of the Intercritically Reheated Coarse-grained Heat Affected Zone of 13MnNiMoR Steel....Pages 887-894
Effect of Niobium on the Static Recrystallization of 5Ni Cryogenic Steel....Pages 895-901
The Development of Ni-Containing Cryogenic Steels and Their Industrial Manufacturing....Pages 903-909
Development of −50°C High-Strength and High-Toughness Nb-Bearing Steel for Large Sphere Tank....Pages 911-915
Front Matter....Pages 917-917
Fuel for Life: Aluminum Energy Technologies for Electricity Generation by Hydrogen....Pages 919-924
Back Matter....Pages 925-932